Driver’s view: Versatile Delta Track 550 offers brawn on a budget

When Case-IH chose to bolt four track units to one of its articulated prairie monsters it created a new tractor concept that had no direct rivals for more than 15 years.

At its launch in the mid 1990s, the Steiger-based 9000-series Quadtrac carved itself a new niche, offering lower ground pressure and narrower working widths than its wheeled ancestors.

Its smooth headland turns and impressive grip also won over many twin-track tractor fans, helping Case-IH to sell more than 560 Quadtracs over the past 20 years.

See also: 2017 tractor and telehandler prices updated

But with the arrival of Versatile’s Delta Track in 2013 and John Deere’s 9RX in 2015, the market leader no longer had the playing field to itself.

To find out how each of the young guns compares with the old-timer, we caught up with each machine’s operator.

This is far from a direct comparison, but gives each operator’s opinion of his tractor.

Versatile Delta Track

Sam Smales, Manor Farm, Hull 

Sam Smales farms arable and potatoes with his father Andrew and grandfather Jack.

They grow spuds under contract for McCain as well as supplying their Frying Farmer fish and chip shop in the nearby village of Aldborough.

The farm’s frontline tractor is a 2016 Versatile Delta Track 550 on 650 hours.

Sam Smales (left) and driver Jonathan Huntley © James Andrews

Have you had crawlers before?

Before the Versatile we ran a couple of second-hand Case Quadtracs that gave us a fair bit of trouble.

We had our first in 2007, a 2003 STX450, and after we’d done three seasons with it and it had clocked up 8,000 hours the gearbox went bang.

We sent it away to have a new transmission fitted, which set us back about £30,000, but shortly afterwards the engine blew up, too.

While we were working out what to do with it we bought another second-hand STX 530. That was a 2007 model on 4,500 hours and after we had put 1,000 hours on it the gearbox went on that one, too.

To be fair to Case, we didn’t know how these tractors had been treated before we had them and they tend to get some stick on our heavy clay ground. However, after that trouble we thought we should probably change tack.

Why did you buy a Versatile Delta Track?

With two knackered Quadtracs sitting in the yard, we were at a bit of a loss as to where to turn next.

We started to look around for a replacement engine for the 450 and that’s when we came across James Hunt at JPM Agricultural. He offered to take in the two broken Quadtracs as a trade-in against a new Versatile Delta Track and the deal looked pretty attractive.

We also priced up a new Quadtrac 620, but the fact that the Versatile was tens of thousands cheaper and came with a five-year warranty was just too attractive to ignore.

Clearly the Case is a more powerful and sophisticated machine, so it’s unfair to compare the price directly.

Other things that attracted us to the Versatile was the fact it had a Cummins single-cam engine (unlike the more complicated double-cam in our old Quadtracs) and a beefy 16-speed Cat powershift transmission that’s rated to take 1,000hp. It’s also got Camoplast track units, which have a pretty good reputation.

How has it performed so far?

We took delivery of the tractor in August 2016 and put it straight to work on our nine-furrow Lemken semi-mounted plough. Immediately we noticed that it had a much smoother gear change under load than our old Quads.

In those, the transmission would smash into gear with a bang when you were pulling the plough and you would almost come to a stop. It’s hard to know how much of that was down to wear, though.

The Versatile, on the other hand, changes quickly and you don’t lose much of your forward momentum.

A lot of our ground is stiff stuff and it pulls the nine-furrow plough just fine. There’s enough power that the tracks will start to lose traction before the engine is dragged right down, but it has to be pretty greasy on the top.

The fact that the fuel tank is in the middle of the tractor also means its weight distribution stays the same as the fuel level drops, helping it to maintain grip.

The Quadtracs had the fuel tank at the back and we used to find they would slip the rear tracks as the fuel level dropped towards the end of the day.

What options did you go for?

The Versatile is a pretty simple old lump, so there’s very little in terms of options. We did spec a rear linkage, but turned down the option of a pto.

We also had it fitted with Agleader GPS that is programmed to work with a Trimble receiver.

Our tractor came on 30in Camoplast tracks, which have a more aggressive tread pattern than the ones on our old Quadtracs. We also used to find cleats got ripped off on those, so we hope the Camoplast units will last a bit longer.

Versatile Delta Track controls © James Andrews

Best and worst features?

The best thing about the tractor is how simple and tough it is. Most of the components are well proven and they have basically been bolted together by Versatile.

The fact that it is so much cheaper than both the Case and John Deere is another bonus, as well as the five-year warranty.

From a driver’s point of view it is not as slick as a new Case Quadtrac, but it does have the edge over the old ones.

For a new tractor, the controls are very basic and there’s not even a depth stop on the rear linkage control. We resorted to drawing marks on the controller with a pencil to make sure we got in the correct place.

Another particularly irritating part about the cab is the fact that the door opens directly into your face, so you have to duck underneath it.

You also can’t see the corners of the front tracks, which means you have to guess where they are when you drive through narrow gateways or when driving past parked cars.

Versatile hasn’t fitted a decelerator pedal either, so you have to drop down the gears on the headlands leaving the engine revving away.

However, all of these little things don’t really matter considering how much we’ve saved, as long as it proves to be reliable.

How long will you keep it for?

As we’ve got the five-year warranty, I think we will keep it until that’s up. We tend to do about 800 hours a year with our frontline tillage tractor, so it should be on about 4,000 hours by then.

If it holds together in that time and doesn’t give us too much trouble there is a good chance we would have another one.

Jack and Andrew Smales’s Versatile Delta Track 550

Engine: 15-litre Cummins QSX15 six-cylinder with EGR

Rated power: 550hp

Max power: 591hp

Peak torque: 2,779Nm

Transmission: 16-speed Caterpillar powershift with 35kph transport speed

Base tractor weight: 26.7t

Max operating weight: 27.8t

Track width: 30in

Year: 2016

Engine hours: 650

Likes

  • Good grip
  • Smooth gearshift under load
  • Competitive price

 Gripes

  • Basic controls
  • Poorly designed cab door
  • Can’t see corners of front tracks